1989 Gt 200 Johnson Outboard Motor Manual

Here is a FREE manual for a Johnson or Evinrude outboard motor. If you have a Johnson or Evinrude outboard this is the repair manual. Normally you would have to pay some scum on ebay or somewhere for this, but we could care less. So here it is for free. Nothing is worse than having a boat that doesn't go in the water. Hope this helps you get it. Workshop Manuals & Owner's Service Repair Manuals for Johnson & Evinrude Outboard Marine Engines For 2-Stroke, 4-Stroke Motors From 2-300 HP.

This is the best Evinrude Outboard Forum on the internet, it's yours! Are you looking for good advice about your Evinrude outboard engine problems and issues. All you need to know about your outboard engine issues and good advice from your fellow boaters.

From outboard engine and electrical and electronics systems to engine and alarm issues, tilt and trim issues, this is the place to find information.

Evinrude Outboard Forum

So where do you start? There is a lot to know. I get asked regularly about what is the problem, and more importantly and how to fix a problem. I am a boat owner and that’s why I have published a dozen books to tell you all that you need to know about how to take care of your boats and systems.

My name is JOHN C PAYNE, and many of you may already have one of my books on marine electrical and electronics systems (The recently published Marine Electrical and Electronics Bible now in it’s 4th Edition) or perhaps one of the many other books on sailboats and yacht systems.

The Evinrude Outboard Forum for Answers to Questions

I am not an armchair expert, but a qualified and practicing marine electrician and engineer and a marine surveyor. I do this for a living. Let this website help you with the boat forum! Thousands of people input with answers to problems.

What is your outboard problem? If you know what the problem is then you are halfway towards finding the right solution. Why not choose from one of my many books to help you fix your problems. Here are some hot topics for the boat-forum:

This is just a fraction of the 3000 plus questions that were posted, and it is hoped that this NEW forum and bulletin board does the same.

The Forum is also a great place to look for spare parts that are hard to find, share your problems and experience with others, ask questions, share stories and more about my books and related topics and a lot more. Create your own web page every time you submit an article and include great low resolution images as well.

How to Post Questions to this Evinrude Outboard Forum

Forum Editors Forum Rules! Yes there are a few basics when posting!

1. DONT TYPE IN ALL CAPITALS as it will not be posted. Don't use any HTML code as it will be deleted

2. Don't use bad language or profanity as it will not be posted.

3. To post to the Outboard Forum please at least use a first name and location with your email address in the notification page, so you will get a message when someone leaves a comment.

4. You need to insert a couple of sentences describing you problem and add an image if possible as it helps others. If you insert just a couple of words using SMS speak the system will reject it.

5. Don't Spam the site with multiple submissions.

6. We receive dozens of posts a day and it is quite impossible to reply to more than just a few given this is a free site and I don't have enough time given I have a day job.

7. It helps if you start the headline with your Evinrude outboard engine make/model number or boat make/model number. Save the problem description to the text, more detail means better answers.

Do You Have Evinrude Outboard Engine Problems?

Do you have outboard engine problems? Share it on the Outboard Forum! Whether you are looking advice on an outboard motor or a difficult marine electrical or electronics technical problem then post your story or message here! UPLOAD AN IMAGE OF YOUR PROBLEM EQUIPMENT! Give us a detailed description, short 5 word posts are not much use and will not be posted. Put your boat info, outboard make and model or basic detail in the post title.

Have an Evinrude outboard problem to share?

Outboard engine problems and issues? need someone to try and help resolve them? Then use this forum and maybe someone can help.

What Other Visitors Have Said

Click below to see contributions from other visitors to this page...

Evinrude 50 hp. 2000
The other day, shortly after starting my Evinrude 50 hp oil injected 2 stroke motor with carbs, the motor died and wouldn’t restart. Today, I starting …

Evinrude E90HSXAF 2020
AJ in Alberta Canada at ic4u.inspections@gmail.com Evinrude 90 HP HO (High Output) bought a Evinrude motor and the dealer states it is a 2020 but the …

Evinrude etec150 2010
The motor only has 130 hours it will be running fine when it all of a sudden will lose power it doesn’t shut down I bring throttle back towards neutral …

Evinrude xp 150 vro 1985
Had fished all night motor ran great mid morning battery was dead swapped batteries it fired right up on the pad in seconds ran about a mile to cabin no …

90 hp Evinrude etech alternator problems
Went out fishing on Erie Saturday only to get stranded halfway through the day because my starter battery was dead I jumped it and got it running and kept …

150 Evinrude Intruder shuts off for no reason
The boat starts fine, idles fine, and accelerates fine. Gets up on plane and once you hit about 30 mph it cuts in and out then shut off like you turned …

40 HP 1989 Evinrude starts then wont start
My 40 HP 1989 Evinrude motor is odd, I can crank it over and over and it will not start, I have checked for spark and there is no spark. I let it sit for …

1976 70 HP Evinrude won't go past 2000 RPM
I have a 1976 &) HP Evinrude that was stored for 7 years. It only has 470 hours on it, as the previous oner kept a complete log of all the fuel used. …

Evinrude, 130hp Etec 2008
I purchased boat 2 days ago and was in bass tournament today and after no issues all morning I pulled into cove and when I went to trim up engine there …

1983 15 hp evinrude Not rated yet
Engine starts best while in foward but wont hold idle. Just rebuilt carb and ran fine. Even started on first pull. Now I cant get it to idle in neutral …

Evinrude E-Tec 50HP 2010 (Tiller) Not rated yet
As I was driving across the lake yesterday, my outboard began to run very roughly. It started knocking pretty hard and eventually started making a grinding …

1996 Evinrude 150 Not rated yet
Motor starts and runs good. Sit for a while and then just cranks. Sits for a while longer then starts up and runs good. Then wont start. Frank’s but won’t …

Etec 225 2005 Not rated yet
Hello. When I am using the tilt/trim at high rpms the motor is stumbling, meaning it is cutting in and out. When I take my finger off the button it goes …

Evinrude 4706B 1978 Not rated yet
Have recently acquired a 4 hp evinrude that wont start, I'm told the guy was going across the lake full throttle and it died on him, never started again. …

Evinrude 225 HP outboard 1989 Not rated yet
engine at full throttle varies from 4200 rpm to 5500 rpm with no movement of the throttle. This just started to occur on our last outing. It runs mostly …

1989 evinrude 48 pre mix Not rated yet
my motor has a hollow sound at idle comp is 135 in each lower unit and water pump rebuilt 31 mph on 16 ft v hull with 15 in prop good hole shot idle is …

evinrude 60173 1971 Not rated yet
1971 Evinrude 60 HP (60173) Cannot find accurate documentation, user manual, images, or related owner maintenance information. Also, do not understand …

Evinrude Big twin electric start 1957 Not rated yet
It will start and run only when in forward. In neutral the shifter lock prevents the throttle from advancement from slow to the start position.

evinrude e70elcsa 1980 Not rated yet
my engine starts ok but will not select forward gear the control lever and control rods all checked and correct dis engaged from gear shift on engine …

300 hp gen2 2019 Not rated yet
Hard to start, turn the key,jiggle shifter and keep turning the key switch a few times and then it will start, also private network communication error …

evinrude 200xp but what year or model Not rated yet
hello all. jst bought a stratos vt rocket and apears to be the only one in the uk. i know its a evinrude xp 200 but im cant establish what model or …

1993 Evinrude 115 HP - 2 Stroke Model TE115TLETS Not rated yet
I have a few questions. Let me start by saying I appreciate any help. Can you recommend the best place to obtain a Service Manual. *pdf is ok. …

1985 evinrude 235 hp crossflow Not rated yet
working on replacement vro injection conversion fuel pump i have the pump theres no markings a all no instructions need to know which barb fitings are …

1957 ? 35 HP Evinrude Electric Start Not rated yet
My serial number is 25930-18-356. I believe the 25930 stands for 1957 but what do the other numbers represent? Karl karlpeterson747@yahoo.com Hendersonville, …

Evinrude 75 hp e tec 2011 Not rated yet
When I use the up switch on side of motor it blows the fuse under the flywheel. It only does it when motor is running. Motor switched off motor goes up …

Evinrude V4 140 1989 model Not rated yet
My 1989 v4 140 is almost impossible to start but when it does start it dies soon as it goes into gear. I've changed the plugs so I'm kinda at a loss and …

100 Evinrude, 1998 year model Not rated yet
Initially the bulb primes good and the boat cranks and runs good. After running for a few minutes the bulb will get soft and the boat seems as if it's …

70HP 1974 Evinrude outboard Not rated yet
When starting out slowly, it seems to misfire and when it runs for a while and we stop, it won't start until it cools or we keep cranking it with the choke …

1992 175 evinrude intruder 175 Not rated yet
It has a miss or no power a studder like at 2000 to 3300 rpm but when on plane it seems to run ok. I have adjusted timing syn and link carburetor it has …

Evinrude V6 150 1989 Not rated yet
Starts, idles, runs great until it’s under heavy load (just before plains out) then it bogs down like flooding out. Changed fuel, fuel filter, cleaned …

Evinrude, V6 150, 1989 Not rated yet
Idles great, starts up fine, in neutral will go all the way up through throttle range however when in gear under a load will not reach full power. Will …

Evinrude Fisherman 6hp 70's Not rated yet
I bought this used and I'm having trouble figuring out why it won't till forward. I pushed the trim lock release lever But it won't tilt forward.There …

40655R Evinrude 1976 Not rated yet
I'm trying to figure out if this motor even has a thermostat nothing is wrong but I see that it should be checked frequently cooling works fine motor does …

Evinrude V-4 115 60° 1995 Not rated yet
Completely rebuilt carbs, good compression, new spark plugs, new VRO pump, new gas line, and new fuel filter. I am running a 18 pitch raker prop and my …

Evinrude 225 outboard 1986 Not rated yet
Had motor running tryed to start back and now its not firing jiggled wires on switch under center console and it firef and ran now its not firing again …

115hp 1985 evinrude Not rated yet
I rebuilt the engine 2 specs with a C lock manual 120 lb in each cylinder engine will not rev the top RPMs it only does about 20 miles an hour on a 15 …

Evinrude, E70TLCEM, 1989 Not rated yet
Replaced rectifier and it now shows over 16.4 volts charging. Tilt and trim has now stopped working. Could this be to the 16 volts harming the T&T motor? …

1990 Evinrude 150XP Not rated yet
I recently serviced and replaced the water pump on my motor. Once I put the muffs on it, turned on the water and started it, water is coming from multiple …

1996 evenrude intruder 150 hp Not rated yet
I have a evenrude intruder 150 hp. When i put it on the water the boat runs fine. When i stop to fish for at least 30 min or so on.i start back up to take …

E90tlcte Not rated yet
Hi, overall motor is running very good but on occasion when idoling the motor will cough or sneeze. This occurs occasionally. After recent work I'm told …

Evinrude BE10RELEDD 1996 Not rated yet
My engine runs sweet as a nut but when I stop it, it won't restart for hours and there is a smell of petrol. When it does fire up again, it runs perfectly, …

1981 evinrude 25 hp outboard Not rated yet
the motor will run fine for about 20 minutes. Then it gets hot and shuts down. Water is coming out of the pump indicator. I replaced the thermostat …

Johnson 70 seahorse 1978 Not rated yet
I can get it to crank over just fine for a few cycles. Than it stops cranking all together. Starters new, solenoid is new and battery is fully charged …

Evinrude Starflite 85 hp 1973 Not rated yet
I believe this is a 73 but have yet to be able to find a serial number, part diagrams seem to match up though. The problem I am having is the motor is …

E50BELCNR, Evinrude 1982 50hp Not rated yet
When motor is brought up to RPM it stops peeing...new impeller kit installed, new thermostat, new pop-it valve gromet and spring.

Evinrude Ficht 150 hp 2001 Not rated yet
Engine starts and runs good until I turn it off. When I try to start again within a few minutes it goes through the pre-start diagnostic checks then it …

Evinrude, E90SLEO 1995 Not rated yet
Engine has started knocking when in gear. It is not very loud and somewhat inconsistent but frequent. Engine starts fine, and runs fine. I had the impeller …

1981 Johnson 9.9 J10RCID Not rated yet
While testing in a tank after replacing power pack and coils, the engine seems to run fine at idle, a little smoky, but runs fine, except - after it warms …

97 evinrude 3 hp outboard Not rated yet
Motor set couple years, tried running it again motor fires up fine takes off after about a minute it floods out and dies ,then gas comes out of the carb …

Evinrude, E200STLCCM, 1988 Not rated yet
Charging problem with check showing problems with Rectifier and Stator. Replaced both. After reassembling with key-way of fly wheel lined up properly, …

Evinrude 25 HP 1990 Bass Tracker Not rated yet
Not starting. Got stuck out on the water when we turned it off to fish a spot We think it might be the Starter Relay or selenoid. The starter motor still …

1996 E50TLEDS Not rated yet
Ignition. What does the purple and white wire with the connector go to 1996 50 horse Evinrude.this wire is coming out of the ignition

2002 Evinrude 225 H>O> Not rated yet
Installed a remanufactured power head after my original lost a ring locator pin. Have it all together but cannot get my injectors to inject. I have power …

1993 Evinrude9,9 Not rated yet
I have a great 9.9 that has sat for about 1.5 years, it will start with carb spray and putters out after 5 seconds. I found out the car needle was turned …

1978 115 hp evinrude model 115899 Not rated yet
after driving for 15 to 20 mins motor will rev up and take off. doesnt happen all the time , i know when it happens it starts to run on all 4 cyls. the …

Evinrude E25DT SLABB 2014 model Not rated yet
Motor starts and runs great for 5 to 10 minutes, then shuts down. Light for high temperature comes on but I don't feel it is that hot. Just brought back …

evinrude 70 E70TLENDA 1996 Not rated yet
the motor starts and runs fine until you go full throttle, it will go full throttle for a couple minutes and then it just cuts out and shakes the motor …

93 evinrude 40 hp Not rated yet
no spark at plugs at all. disconnected the black and yellow wire. no change. checked all the grounds they were good couldn't get any volt reading out of …

Evinrude Model # 60552C Yr/serial # C457054 Not rated yet
We just purchased this 1065 2 stroke 4 cylinder Motor I am looking to find the following; 1 Owners manual and parts list 2 After market or original …

E30ELCOA 1985 Not rated yet
bought used -no remote control. Added Amarine 500618BRP remote control + new cables and adapter kit (recommended) Battery is good: power is to motor: …

Evinrude 50hp 1998 Not rated yet
It’s on our pontoon. Starts out running like new. Then in 15 Minutes runs sluggish. And we hope it will make it back. We changed the spark plugs and …

1995 Evinrude 35hp 3 cylinder Not rated yet
engine runs rough at idle but runs perfect in gear. Oiler has been removed, new cdi pack. New thermostat and sensor, water impeller new, 115 across all …

Johnson 8 hp model cj8rcud Not rated yet
Engine was serviced and stored about 3 years ago. It will not run on it`s own only when you spray fuel into the carb. I have had the carb dismantled twice …

evinrude starfligt 85hp 1972 hydro-electric shift Not rated yet
motor was runnin great but would have an intermittant .. i know with these wiring conn. are cridical.was checking out for conn when noticed coil was cracked. …

1977 Evinrude 70 HP 70773S Not rated yet
This old barn find engine is in near mint condition. It had set for maybe twenty years in a garage on a 16'VIP tri hull. I bought the boat two years ago …

Evinrude E10RLG4AFA 9.8 BRP 2016 Not rated yet
The motor is on a 24 foot sailboat. The engine began to stall at idle, then would no longer start. I just took the carbeuretor off and find that it has …

evinrude 1990 90 hp Not rated yet
Running the motor on a 20 ft pontoon runs smooth then a sudden jerk like hitting a log. then runs smooth for three minutes or so and jerks again sometimes …

6 horse evinrude mod e6rcec 1998 Not rated yet
Just bought this and have been able to get it running in a barrel, so I know it's not junk. Handle information I'd worn off so not even sure how to start …

1996 evinrude e90sledr 90hp ocean pro Not rated yet
had water leak above starboard side thermostat removed head cleaned and replaced orings and thermostat and thermostat seal in head ran motor still leaks …

Evinrude 150hp co,1992 Not rated yet
I took my starter off before I had the new starter now I have to wire. I don't know where they go one is coming out of the top of the motor by the stator …

Evinrude 1984 V4 90 Not rated yet
Our 1984 Evinrude V4 90 hp stator puts out 12.2 amps for a short while then goes to around 15 amps as we gain speed. I have replaced the stator, resister, …

Evinrude angler 1965 5 hp Not rated yet
The motor looks brand-new was told it was serviced two years ago. Tried to get it running with fresh fuel and oil. Will turn over run for a few seconds …

1968 evinrude 9.5 sportswin Not rated yet
I bought this motor off of a friend a couple weeks ago, he said it hadn't been started in 3 years but it worked great when it was running, when I got it …

Evenrude, E-etc 40, 2019 Not rated yet
I have a brand new pontoon with a Evenrude E-etc 40 engine. Engine runs rough at mid rpm’s. From about 2600 to 3500. Above 4000 rpm runs fine. From …

1973 Evinrude V-4 115 hp outboard. Not rated yet
Charging issues. I recently purchased the boat and motor. I first resealed the lower unit, and replaced the impeller before starting it. (as it had set …

Evinrude 1973 85 HP model 85393m Not rated yet
I have replaced the stator, timer base, power pack,all 4 coils, all spark plugs. I rebuilt the carbs and replaced all 4 reed valves. IT has an occasional …

1981 Evinrude 60 e60elcih Not rated yet
Engine quit while tubing, found broken wire and brittle wire sheaths on most of the cdi harness wires. Bought new harness and installed as shown. Have …

evinrude 140, E140TRLCTE serial number J0285636 Not rated yet
seems like when i put the shifter all the way in forward position it does hit max speed . like a cable adjustment is needed slightly. it does go in forward …

1993 evinrude 8 HP 2 stroke Not rated yet
I was operating at WOT across a lake for about 20 minutes and motor was running fine. All of the sudden it died like the kill switch was pressed. Would …

Evinrude 115FPSLO 2005 Not rated yet
I am new to motor boats. This is a new to me boat and engine. We ran the engine with a water hose during the purchase process. There is a constant 'No …

1990 Evinrude 70HP VE70TLESB Not rated yet
Motor runs perfectly most of the time. However, it often dies during low speed maneuvering (docking or loading on the trailer). I had a local marina …

Evinrude E50JED 1996 Not rated yet
Will not start when air temp is cold/cool but when air temps warm up it will start on the first crank of the motor. Replaced the ignition switch a month …

Evinrude 48 horse 1991 Not rated yet
Evinrude 48 horse 1991 replaced everything having to do with Stator Twice engine cranks and runs fine at idle rev up engine to 1500 RPM and both Coils …

2013 etec 150 Not rated yet
Engine started fine at marina, ran 40 minutes out to fishing grounds, drifted 1/2 hour, went to restart and wouldn’t fire, had to try 5-6 times, ran 5 …

Evinrude 8hp E8RCUD 1987 Not rated yet
After 3 hours on the lake it will start right up but will shut off when I accelerate...if I milked it it will get me back but doesn't run full power and …

Evinrude 9.9 1988 Not rated yet
Can you change the head gasket without removing the engine from the cowling? What about the engine mounting on the corner of the cylinder head, please? …

1995 Evinrude 115 hp V60 Not rated yet
I have a 1995 V60 Evinrude 115 hp motor that needs a new lower unit. I have checked around and have seen different ones on Craigslist. My questions are …

Evenrude E30REUD 30HP 1996 Not rated yet
Once engine is warmed up it cuts out at higher speed, starts and idles fine.Some background, battery was hooked up backwards once. Perhaps this was start …

115 Evinrude Ficht 2003 Not rated yet
My 2003 Evinrude will plane for about 100 yards then will slow down and spudder as if it's not getting enough fuel. The primer bulb will also go soft. …

evenrude e225fhlsif 2001 Not rated yet
number 1 cylinder is sparking on all cylinders except number1 and the number 2 cylinder is not sparking. When I do a static check the no. 2 sparks and …

1969 Evinrude V6 Buick Inboard Tilt Motor Not rated yet
Hi, I am looking for an OMC Stringer Tilt Motor Coupling for a 1969 Evinrude V6 Buick In board Motor. 400 800 Hammerblow ... OMC Stringer Coupling …

evinrude 200xp 1991 Not rated yet
Odd miss after sitting through winter. Sometimes runs perfect..then at times will miss..then at times at speed will die out but take your foot off pedal …

91 Evinrude 60 E60TLEIB Not rated yet
Needed a powerpack for another boat. Pulled off of this motor because needed it that day. Replacement came in and getting fire but won't start. Pulled …

evinrude ,E40DPLSCB,2008 Not rated yet
I bought spark plugs at local auto zone store.They gave me NGK # 4095 or # IZFR6F11 to replace Champion # QC10WEP or # 9005 spark plugs. They cross reference …

Evinrude etec 2010 40 hp Not rated yet
Winterized engine end of 2019 season and stored in heated garage. Engine in water at idle and low speed runs perfect. No spitting or cutting out. When …

1976 Johnson 55 hp Not rated yet
It takes awhile to start and it is hard to put it in gear without shutting off. Once it goes into gear without shutting off it will run fine for awhile …

evinrude 25202r 1972 Not rated yet
I had the motor running 2 years ago. I put a new waterpump impellor and did not run it until now. trying to start it it acts like a bigblock chevy way …

2004 Evinrude E TEC 225 HP on a 2004 Ranger Comanche Not rated yet
Motor just stopped while driving at a speed just above idle speed. Put it back in neutral, and will not start. Starter does not attempt to engage. …

Evinrude E35ECSM 1980 Not rated yet
this engine is electric start. It runs for a couple minutes and then floods out. I replaced 1 coil due to no spark on 1 cylinder and now has good spark …

Evinrude G2 2018 Not rated yet
I am having issues with my trim. Worked great going downward, struggles/sounds like a power issue going up.... but only right before it hits 80% trimmed …

Evinrude etec 75hp 2009 Not rated yet
The the motor is like new condition with 37 total hours. always kept indoors. And the EMM quit charging the battery. Which means a total replacement of …

1989 Gt 200 Johnson Outboard Motor Manual

Evinrude e175exeuc ocean pro Not rated yet
Eng I always runs great. Problem I have is after running operation at temp shut off to fish or eat for 1 hr approximately go to restart starts idle put …

1995 evinrude 200 hp ocean pro Not rated yet
On the bottom rear of my air box there is a small fitting with a rubber hose on it it then goes into the engine block. My prolbum is when I raise the motor …

Evinrude 200 xp 1990 Not rated yet
Ok. The motor starts fine everytime. The motor planes fine when it is first started. After, fishing for a while. When you go to get on plane it bogs down. …

evinrude 35 hp model e35elcsm 1980 Not rated yet
what is the best way to bypass the electric harness plug on the engine that has rotten wires on one side of it. Thanks for any help.

Evinrude 88 spl 1987 Not rated yet
Alright so I have a 1987 evinrude 88 spl, it sat for almost 3 years, I changed all the coil packs and the plugs and cleaned the carbs and out a new battery …

Evinrude E90TLCOS Not rated yet
Hi all! Fresh water boat. Light coating Whitish foam on top right spark plug.pulled water jacket cover it was crusty white and grainy. Pulled off cylinder …

2012 Evinrude Etec 175 DPXINE Not rated yet
Replaced throttle and shift cables, all spark plugs, fuel filter, new key switch, and new binnacle. Engine started prior to replacement of said items. …

Evinrude, E150FPXS0C, 2005 Not rated yet
I have twins 2005 150hp Direct Injection motors and do my on maintenance and service. I was opening the boat from winter and when I'm starting my starboard …

Evinrude outboard 3 hp light twin, roughly 1960 Not rated yet
On the engine it says use 30 weight outboard oil ,This is a gas oil mix. Is 30 weight outboard oil a specific oil. Or May I use straight 30 weight. That …

1979 evinrude 2 stroke 85 hp Not rated yet
tachometer not working properly,i had a broken rectifier i have replaced with new one, i have 12 volts going to my tacho but soon as i start my engine …

Evinrude 1956 30 H.P. Not rated yet
Has been running great for many years now. But now when in forward gear, a hard vibration starts and pushes the gear lever back toward neutral. In reverse …

Evinrude 25 hp 1976 Not rated yet
1976 Evinrude 25 hp was running great and all of a sudden lost power and I put it in neutral and it cut off. Got it cranked back up but had no power. Really …

evenrude e225fhlsif 2001 Not rated yet
found a cylinder with no compression used a borescope and I can see a broken ring. I have contacted 3 different marine repair shops and they will not work …

Evinrude E50TI EDS 50 hp 1996 Not rated yet
I started my 1996 50 hp Evinrude today for the first time in almost 6 months. It started after a few attempts, as expected, and then began to run. I had …

1989 88 spl Evinrude Not rated yet
Change impeller and it lost fire so I pulled the plug wires and check fire and it is strong so I put fuel to it . This was today it’s been sitting for …

Evinrude 130 hp four cylinder 1997 Not rated yet
The engine blows the 20 amp fuse at odd times. Some times while idling and some times while at high speeds. I loose trim and tilt all gauges and if shut …

Evinrude triumph 55hp 1969? Not rated yet
Cant start ,sparks good, fuel to pump, will check compression and fuel to pistons and plugged exhust, tomorrow. Cleaned up some bad ignition wires started …

evinrude 140 1977 Not rated yet
The electric choke does not work I checked the solenoid with a battery and it works. Could the starting switch be the issue?

Evinrude intruder 175 E175glera 94 Not rated yet
I rebuilt carburetors and put a new power pack on it . It has been hard to start since I got it so I cleaned the plugs and I do have spark. I have not …

Evinrude 48 spl 1996 Not rated yet
Bought the motor and it ran good whenever I out it on my boat the it didnt sound right so I took it to the local mechanic who is a year out on jobs. He …

Evinrude 40hp 1995 Not rated yet
Hi, I just bought a boat with a 1995 Evinrude 40 hp 2 cyl. It had a leaking fuel primer/choke that I repaired and it will run good at high rpm but will …

1989 evinrude 150 E150STLESB Not rated yet
Starts up good, and is missing tough to get on plane when it is on plane runs smooth. Changed fuel filter and plugs, took out plugs and they all spark. …

2011 evinrude e-tec 130 HP Not rated yet
1. Starts quickly 2. Idles smoothly 3 Accelerates strong normal 4. run 3/4 speed for 1+ mile 5. engines suddenly quits - dead 6. will start after 10 minutes …

2000 Evinrude 250HP - Thud in motor while moving only Not rated yet
Last summer i replaced the power head on my 2000 evinrude 250HP with a used one. It ran fine the 1st time I used it it, then started feeling a hard thud …

1993 Evinrude tracker 90hp throttle/control problem Not rated yet
Changed throttle/ gear cables 1993 evinrude tracker 90hp. Now when I shift forward or reverse gear will only go forward. Help

1975 70 hp evinrude toggle switch choke Not rated yet
I have a 1975 70 hp evinrude with a toggle switch for the choke. Can I convert it to a newer ignition switch with a push to choke? The current ignition …

1977 Evinrude 9.9 Not rated yet
I just picked up a 1977 Evinrude 9.9 for my 14' MFG car topper. The gent I bought it from said it has not moved from his basement in 40 years and it looks …

Evinrude Etec 130 bad fuel consumption Not rated yet
Hi, i have boat fisherman 22' weight cca 900 kg with evinrude 130hp etec 2011 year and my max speed is 29 knots on 6000rpm with solas prop rubex ns3 13 …

1992 evinrude 25hp starter only works in short bursts. Not rated yet
Starter will turn fast but bendix drops down after about a second or so. Not a problem once the motor is warm , but , cold starts take a bit more cranking …

Stator Output: 87 evinrude 110 VRO Not rated yet
Chasing a no spark, stator and timer both pass resistance tests. Port side stator wire reads 0v with DVA output test and hits 300v on the starboard side. …

76 evinrude 35 model 35653g no spark Not rated yet
I have replaced ignition coils driver coil condensers and point and spark plugs but I can get no spark it just turns over forever! Points are set .020. …

70 hp Evinrude 2 stroke Quintrex aluminum 4.5 Not rated yet
Hi all have a 4.5 aluminium quintrex 70 hp evinrude 2 stroke and 9.8 4 stroke long leg aux took fuel tanks out placed a poly 60 ltr under floor tank to …

1978 70hp Evinrude dies when I throttle up? Not rated yet
Restoring an old boat and the motor turns on and idles like its brand new.(1978 70 hp Evinrude) I have replaced power pack kitted and cleaned the carbs. …

1989 evinrude 150 cracked motor mount plate Not rated yet
hello. we have an evinrude 150 vro that developed a crack in the starboard side plate that I am told covers the lower motor mount The crack has extended …

1988 Johnson 200 Hp Outboard

175HP Evinrude Direct Injection 2002 Not rated yet
Hi first time here, just seeing if I could pick up some advise on my 2002 175HP Evinrude Direct Injection, firstly I have come to learn that these engines …

‘96 90 horse evinrude Not rated yet
Relatively new power head (last year). Going across the lake about 20 mph. Engine died with metallic sound. Some time later, I started and limped back …

115hp Evinrude What pitch propeller should I use? Not rated yet
I bought a 1984 lund tyee 5.3 with a 115hp Evinrude. I am wondering what pitch prop I should be running. I have a 19 pitch on it now, it had a 21 when …

1970 evinrude 40 hp big twin won't start Not rated yet
Bought boat to recondition put new battery in cleaned all connections when key is turned to start position engine would only click after trying 5 times …

1980 Evinrude E100tlcsc Tach problem. Not rated yet
I have an 1980 Evinrude (E100tlcsc) and the Tach is driving me insane. When the engine is first started the Tach reads fine no jumps or ticks and in less …

Evinrude G2 300 HP Outboards Not rated yet
I have a 40 foot alloy lobster vessel, powered by two G2 300's it weighs about 7 Tonne and has a top speed of 40 knots in calm conditions. My problem is …

Evinrude V4 1991 120HP Outboard Craburator Issues. Not rated yet
I am rebuilding the 4 carburetors on my friends Evinrude 1991 V4 120hp outboard. I don't have the engine model number handy as the motor is 300 miles from …

1981 Evinrude 140 sport won’t backfire problem Not rated yet
I have a 1981 Evinrude v4 140 sport that will not run but will only backfire. I don’t know enough about outboards to figure out the problem. I did figure …

1999 200 Evinrude Ocean Pro - 1986 Mako 20 Not rated yet
Hello,Have a 1986 Mako 20 with a 1999 200 Evinrude Ocean Pro. Just replaced both batteries, new stator and water pump. Boat was running great until the …

Evinrude 150 starving for fuel? Not rated yet
My Evinrude 150 runs fine out of the water, but acts like it is starving for fuel when in water and under load. It will not rev up unless the choke is …

1983 75 hp Evinrude Won't start. Not rated yet
Rebuilt all 3 carbs, checked spark and solid blue arc with a 1/2' gap, 100 psi on each cylinder. Will not currently start and after pulling plugs I have …

1991 Evinrude 120 hp e120 won't start Not rated yet
For some reason my boat won't start anymore. It just keeps cranking. I have strong spark and proper fuel and compression. Back story on the issue. I just …

Evinrude 90 hp and 115 interchanging Not rated yet
I am curious if a 1992 90 hp VRO and 1993 115 evinrude can be switched without removing the trim bracket. The 115 has no electric trim so I was thinking …

1967 Evinrude Angler won't stay running Not rated yet
So my boyfriend bought a boat which came with a 1967 Evinrude Angler motor. It needed some work which wasnt a problem. He cleaned the carb inside Nd out, …

Evinrude Etech 225 2005 Many Problems Not rated yet
I recently purchased a used Champion boat with an Evinrude 225 Etech. When I bought he boat the second time I took it out the water temp sensor went off. …

Older model Evinrude outboard motor 25 hp will not start Not rated yet
I have a older model Evinrude motor 25 Hp out board. It has been in storage for several years. It will not crank with the plugs in both cylinders. However, …

Evinrude 15hp 4 stroke obsolete exhaust valves Not rated yet
I all ready had a chunk of money invested in fixing up my newly acquired Evinrude outboard when I discovered I badly needed two exhaust valves (0337241). …

1992 Evinrude 60Hp won’t start Not rated yet
My dad and I just rebuilt the carburetors on our 1992 Evinrude 60hp outboard yesterday. The boat still will not start up but will turn over. Anybody have …

89 Evinrude 225 Not rated yet
Engine seems to have an electrical issue, if I cruise around the lake for a bit and try to go wide open it feels like there's a rev limiter at 3100, if …

100hp evinrude missing Not rated yet
Hello I am having a problem with a 1989 Evinrude E100STLCEM 100 hp motor. When cold the engine is missing on what I think are 2 cylinders. It is very hard …

2002 Evinrude 225 - Starboard engine won't trim up Not rated yet
My starboard outboard won't trim up, but will trim down. Trim motor does not run when trying to trim up but will going down. I have had the batteries …

1997 evinrude 35 hp Not rated yet
Hi I have a evinrude 35 hp power three cylinder engine that acts like I its starving for fuel intermittently .changed fuel can and hose out for one with …

1969 Evinrude 55 hp dies hot then won't restart. Not rated yet
I have a 1969 Evinrude 55 hp that dies when hot and then won't restart. Only thing not replaced is the amplifier (now called CDI). Did find wire from …

86 150 evinrude carburetor problem Not rated yet
My motor runs but I have to pump bubble more than I should have to and noticed it was losing prime. So I investigated and noticed gas continuously runs …

2003 200 HP evenrude outboard Not rated yet
Engine runs for 30-45 minutes. Then engine dies out, get a quick whistle and the oil, overheat and check engine lights up. Wait 1/2 hour restart, run at …

50 hp evinrude 1972 wont crank Not rated yet
electric choke work =s but no crank. Jumped positive to starter and kicked,unplug big red plug and loked for power but couldnt find any even when starter …

175 evinrude falls on its face full throttle Not rated yet
I have a 89 evinrude 175xp outboard boat motor starts and runs great I changed sparkplugs and cleaned carbs will idle up just find and will take about …

1999 Evinrude Motor stops but starts back up right away Not rated yet
My 1999 evinrude motor stops suddenly and can't figure out why. It will run for a bit then stop, but it always starts right back up no hesitation. Know …

Evinrude ETEC 150 HO throttle response Not rated yet
For the first 2 years when I gave the motor 3/4WOT it had a great hole shot. However, a friend was driving the boat and forgot to put it in gear and gave …

1995 25 hp evinrude 2 stroke bogs down Not rated yet
I have a 25 hp 2 stroke evinrude that has an electric start. So the issue im noticing is that when I give it throttle the carb doesn't open up to allow …

15hp evinrude 4stroke 2006 epa standard Not rated yet
Sometimes this motor will get fire and crank on the first pull and others it might not crank for hours or days. But when it does crank it runs like a charm. …

1995 25 hp Evinrude problems Not rated yet
I have a 1995 25hp evinrude console steer runs great but some times it acts like a rev limiter is there when going from neutral too half throttle or so …

88 hp evirude dies when trimmed completely down Not rated yet
i have a bumble bee king bee with a 88 hp spl evinrude that idles fine and runs fine until you trim it completely down it then dies and will not restart …

2004 evinrude e-tech 50 hp Not rated yet
I have a 2004 E-tech 50 hp, it starts and idles great but when you go to throttle up it spits and sputters. I have put new has in and changed both plugs …

1985 60 hp Evinrude cutting out Not rated yet
I have a 1985 Evinrude 60hp. The motor appears to have been set up for oil injection in the beginning, but it was all removed prior to me owning it. We …

1988 evinrude 88 spl coughs Not rated yet
Engine starts up but idles erratic. Upon acceleration, engine cough every once in a while and dies ittermittently. Carbs where overhauled, plugs were …

1986 Evinrude 70 hp wont turn over. Not rated yet
1986 Evinrude 70 HP will not start. I replaced the selenoid coils, the actual selenoid, and spark plugs. I had it started in my yard with the hose hooked …

1998 90hp evinrude spl Not rated yet
I have a 1998 90hp evinrude spl. I have rebuilt the carbs, fuel pump, replaced the filter in the water seperater, all the fuel lines, primer bowl, spark …

1978 evinrude 35 hp...needs new wiring Not rated yet
I have a 1978 evinrude,35 hp motor and alot of the wiring needs replaced. The wiring under the cap has become so brittle that when you move it , it brakes. …

1989 60hp evinrude starting problem when engine is cold Not rated yet
i have a 1989 evinrude 60hp outboard motor that is hard to start when it is cold on some days and it doesn't matter if there is load or not. but once it …

1995 evinrude 88 loads up at steady rev Not rated yet
I have put new plugs,carb gasket, filter,drained old gas cleaned carbs and it will idle for a minute or less and when I hold at a steady rev it loads up …

1989 Gt 200 Johnson Outboard Motor Manual Lift

1986 evinrude 40 hp tilt cylinder assembly Not rated yet
I am rebuilding my tilt cylinder assembly replacing the seals because the fluid leaked. How much hydraulic fluid does it require? Or does anyone know …

Johnson Gt 100 Outboard Motor

1985 70 HP Evenrude starting problems Not rated yet
1985 70 HP Evenrude starting problems I was out in the boat yesterday and noticed the engine laboring and not able to go full throttle even though …

1989 Gt 200 Johnson Outboard Motor Manual Pdf

1980 Evinrude 70HP 3 Cylinder 2 Stroke Help please Not rated yet
I have got a problem that has started recently and is getting progressively worse. Motor was serviced three months ago, new plugs, compression good, carbies …

Old Johnson Outboard Motors Manuals

Evinrude 65 Hp outboard 1991 problem Not rated yet
It has now been happening from the past 3 months. When ever we put the enigne in gear it just stalls. We have shown it to a couple of boat mechanics changed …

1992 Evinrude 48 hp Not rated yet
Novice could use general advice cleaning up neglected small boat to good running condition. 14' aluminum V-hull runabout w/1992 Evinrude 48 hp ... unused …